KRYLON INDUSTRIAL -- 00246, RUST TOUGH RUST PREVENTATIVE ENAMEL (SUPDAT) -- 8010-00N045768 
=====================  Product Identification  =====================

Product ID:00246, RUST TOUGH RUST PREVENTATIVE ENAMEL (SUPDAT)
MSDS Date:02/20/1993
FSC:8010
NIIN:00N045768
=== Responsible Party ===
Company Name:KRYLON INDUSTRIAL
Address:6830 COCHRAN ROAD
City:SOLON
State:OH
ZIP:44139
Country:US
Info Phone Num:800-247-3266
Emergency Phone Num:216-292-7400
CAGE:DO934
=== Contractor Identification ===
Company Name:KRYLON INDUSTRIAL
Address:6830 COCHRAN ROAD
City:SOLON
State:OH
ZIP:44139
Country:US
Phone:800-247-3266
CAGE:DO934
Company Name:KRYLON PRODUCTS
Address:31500 SOLON ROAD
Box:City:SOLON
State:OH
ZIP:44139
Country:US
Phone:800-832-2541/216-566-2917
CAGE:87187

=============  Composition/Information on Ingredients  =============

Ingred Name:HNDLG/STOR PREC:PARTICULATES (LISTED "AS DUST" IN ING
    SECTION) WHICH MAY BE PRESENT AT HAZ LEVELS ONLY DURING (ING 10)
RTECS #:9999999ZZ

Ingred Name:ING 9:SANDING/ABRADING OF DRIED FILM. IF NO SPECIFIC DUSTS
    ARE LISTED IN ING SECTION, APPLIC LIMITS FOR NUISANCE(ING 11)
RTECS #:9999999ZZ

Ingred Name:ING 10:DUSTS ARE ACGIH TLV 10 MG/M3 (TOTAL DUST), OSHA PEL
    15 MG/M3 (TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ

Ingred Name:VENT:LIMITS. REFER TO OSHA STANDARDS 1910.94, 1910.107,
    1910.108.
RTECS #:9999999ZZ

Ingred Name:OTHER PREC:KEEP AREA VENT. DO NOT SMOKE-EXTINGUISH ALL
    FLAMES, PILOT LIGHTS, & HEATERS. TURN OFF STOVES, ELEC (ING 14)
RTECS #:9999999ZZ

Ingred Name:ING 13:APPLIANCES, & ANY OTHER SOURCES OF IGNIT. CONSULT
    NFPA CODE. USE APPRVD BONDING & GROUNDING PROC. KEEP (ING 15)
RTECS #:9999999ZZ

Ingred Name:ING 14:CNTNR CLSD WHEN NOT IN USE. TRANSFER ONLY TO APPRVD
    CNTNRS W/COMPLETE & APPROP LABELING. DO NOT TAKE (ING 16)
RTECS #:9999999ZZ

Ingred Name:ING 15:INTERNALLY. KEEP OUT OF THE REACH OF CHILDREN.
RTECS #:9999999ZZ

Ingred Name:RESP PROT: RESP APPRVD BY NIOSH/MSHA FOR PROT AGAINST
    NON-VOLATILE MATERIALS IN INGREDIENTS SECTION.
RTECS #:9999999ZZ

Ingred Name:MINERAL SPIRITS; VP:2.0 MM HG
CAS:64742-47-8
Fraction by Wt: 41%
OSHA PEL:100 MG/M3 (MFR)
ACGIH TLV:100 MG/M3 (MFR)

Ingred Name:TITANIUM DIOXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 6%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST

Ingred Name:VOLATILE ORGANIC COMPOUNDS:3.50 LBS/GAL LESS WATER
RTECS #:9999999VO

Ingred Name:EFTS OF OVEREXP:(SILICOSIS) & POSS CANCER. PRLNGD OVEREXPOS
    TO SOLV INGRED IN ING SECTION MAY CAUSE ADVERSE EFTS (ING 5)

Ingred Name:ING 4:TO LIVER & URINARY SYS. RATS EXPOSED TO TITANIUM
    DIOXIDE DUST AT 250 MG/M3 DEVELOPED LUNG CANCER, HOWEVER, (ING 6)
RTECS #:9999999ZZ

Ingred Name:ING 5:SUCH EXOS LEVELS ARE NOT ATTAINABLE IN WORKPLACE.
    RPTS HAVE ASSOC RPTD & PRLNGD OVEREXP TO SOLV W/PERM (ING 7)
RTECS #:9999999ZZ

Ingred Name:ING 6:BRAIN AND NERVOUS SYSTEM DAMAGE.
RTECS #:9999999ZZ

Ingred Name:DISP METH:OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
    REGULATIONS REGARDING POLLUTION.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:TO MINIMIZE EXPOS, FOLLOW
    RECOMMENDATIONS FOR PROPER USE, VENT, & PERS PROT EQUIP.
    ACUTE:IRRIT OF EYES, SKIN & RESP SYS. MAY CAUSE NERVOUS SYS
    DEPRESS. EXTREME OVEREXPOS MAY RESULT IN UNCONSCIOUSNESS  & POSS
    DEATH. HDCH, DIZZ, NAUS, & LOSS OF COORD ARE INDICATIONS OF EXCESS
    EXPOS TO VAP OR SPRAY MISTS.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:REDNESS & ITCHING OR BURNING SENSATION
    MAY INDICATE EYE/EXCESS SKIN EXPOS. CHRONIC:CERTAIN PRODS CONTAIN
    QUARTZ. QUARTZ, ALSO KNOWN AS CRYSTALLINE SILICA, IS LISTED BY
    IARC. LONG TERM EXPOS T O HIGH LEVELS OF SILICA DUST, WHICH
    CANOCCUR ONLY WHEN SANDING OR ABRADING DRY FILM, MAY CAUSE LUNG
    DAMAGE (ING 4)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

=======================  First Aid Measures  =======================

First Aid:INHAL:IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BREATHING.
    KEEP WARM AND QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY WITH SOAP
    AND WATER. EYES:FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST
    15 MIN UTES. GET MEDICAL ATTENTION. INGEST:SEEK MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:PMCC
Flash Point:100F,38C
Lower Limits:1.0
Upper Limits:6.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
    PROTECTIVE EQUIPMENT .WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS
    USED, FOG NOZZ ARE PREF. WATER MAY BE (SUPP DATA)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELECT EQUIP, SPARKS,
    AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
    EXTREME HEAT. APPLIC TO HOT SURF REQ SPECIAL (SUPP DATA)

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENT AND
    REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP
    & SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES. THESE COATINGS MAY
    CONTAIN MATLS CLASSIFIED AS NUISANCE (ING 9)
Other Precautions:INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS
    CAN BE HARMFUL/FATAL. CONTENTS ARE COMBUST. KEEP AWAY FROM HEAT,
    SPARKS, & OPEN FLAME. VAPS WILL ACCUMULATE READILY & MAY IGNITE
    EXPLOSIVELY. DURIN G USE & UNTIL ALL VAPS ARE GONE (ING 13)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF PERS EXPOS CANNOT BE CONTROLLED BELOW APPLIC
    LIMITS BY VENT, WEAR PROPERLY FITTED ORGANIC VAP/PARTICULATE RESP
    APPRVD BY NIOSH/MSHA FOR PROT AGAINST MATLS IN ING SECTION. WHEN
    SANDING/ABRADING THE  DRIED FILM, WEAR DUST/MIST RESP (ING 17)
Ventilation:LOCAL EXHAUST PREF. GEN EXHAUST ACCEPTABLE IF EXPOS TO
    MATLS IN ING SECTION IS MAINTAINED BELOW APPLIC EXPOS (ING 12)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
MFR TRADE NAME/PART #:BULKS-1 RT-B/KRI1, SAFETY BLUE (OSHA BLUE). FIRE
    FIGHT PROC:USED TO COOL CLSD CNTNRS TO PRVNT PRESS BUILD-UP & POSS
    AUTOIGNIT OR EXPOS WHEN EXPOSED TO EXTREME HEAT. EXPLO HAZ:PRE C.
    DURING EMERGENCY CNDTNS EXPOS TO DECOMP PRODS MAY CAUSE HLTH HAZ.
    SYMPS MAY NOT BE IMMED APPARENT. OBTAIN MED ATTEN.

==================  Physical/Chemical Properties  ==================

HCC:F4
Boiling Pt:B.P. Text:>300F,149C
Vapor Density:HVR/AIR
Spec Gravity:0.95-1.29
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE:CARBON DIOXIDE, CARBON
    MONOXIDE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER
    RESOURCES CONSERVATION & RECOVERY ACT (RCRA) 40 CFR 261. WASTE MUST
    BE TESTED FOR IGNITABILITY TO DETERMINE APPLIC EPA HAZ WASTE
    NUMBERS. INCIN IN APPRVD FA CILITY. DO NOT INCIN CLSD CNTNR.
    DISPOSE (ING 8)

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.